Anaerobic Fluidized-Bed Membrane Bioreactor for Treatment of Liquid Fraction of Sludge Digestate: Performance and Agricultural Reuse Analysis

Lu Liu, Jun Zhang (), Yifan Chen, Ze Guo, Ganzhan Xu, Linlin Yin, Yu Tian and Stevo Lavrnić
Additional contact information
Lu Liu: National Engineering Research Center For Safe Disposal and Resources Recovery of Sludge, School of Environment, Harbin Institute of Technology, Harbin 150090, China
Jun Zhang: National Engineering Research Center For Safe Disposal and Resources Recovery of Sludge, School of Environment, Harbin Institute of Technology, Harbin 150090, China
Yifan Chen: National Engineering Research Center For Safe Disposal and Resources Recovery of Sludge, School of Environment, Harbin Institute of Technology, Harbin 150090, China
Ze Guo: National Engineering Research Center For Safe Disposal and Resources Recovery of Sludge, School of Environment, Harbin Institute of Technology, Harbin 150090, China
Ganzhan Xu: National Engineering Research Center For Safe Disposal and Resources Recovery of Sludge, School of Environment, Harbin Institute of Technology, Harbin 150090, China
Linlin Yin: National Engineering Research Center For Safe Disposal and Resources Recovery of Sludge, School of Environment, Harbin Institute of Technology, Harbin 150090, China
Yu Tian: National Engineering Research Center For Safe Disposal and Resources Recovery of Sludge, School of Environment, Harbin Institute of Technology, Harbin 150090, China
Stevo Lavrnić: Department of Agricultural and Food Sciences, Alma Mater Studiorum-University of Bologna, Viale Giuseppe Fanin 40-50, 40127 Bologna, Italy

Sustainability, 2023, vol. 15, issue 9, 1-17

Abstract: The treatment of sludge digestion liquid is a big challenge in wastewater treatment. If treated as normal wastewater, large amounts of nitrogen and phosphorus present in the sludge digestion liquid might be wasted when they could be reused in agricultural irrigation and reduce the consumption of artificial fertilizers. Thus, it is of utmost importance to deliver a simple and feasible strategy to treat sludge digestion liquid for agricultural reuse. In this study, a novel type of anaerobic fluidized bed membrane bioreactor system (US-AnFMBR) was developed by combining an ultrasonic processing unit and biochar in AnFMBR. The improvement of sludge properties, removal of pollutants performance and membrane fouling mitigation were achieved in this novel system. The optimal dose of BC (biochar) was 2.5 g·L −1 , and the optimal ultrasonic treatment conditions were 30 min at 26 W. The main contribution of ultrasound was to improve the activity of sludge microorganisms to adsorb and degrade more organic matter present in sewage. The system achieved the removal efficiencies of COD, NH 4 + -N and PO 4 3− -P up to 89.41%, 49.29% and 54.83%, respectively, and had a better mitigation effect in terms of membrane fouling. On the one hand, the biochar addition for COD removal performance was mainly manifested in membrane rejection performance. On the other hand, the combination of low-cost biochar and AnFMBR can also provide new ideas for the recycling of agricultural waste for biochar production. However, regarding the removal efficiency of NH 4 + -N and PO 4 3− -P, the US-AnFMBR system promoted the activity of starved sludge to preferentially absorb NH 4 + -N compared with PO 4 3− -P by statistical analysis. The US-AnFMBR can reduce the viscosity of sludge and release more small molecular substances, thus better mitigating membrane fouling. Long-term operation performance also revealed the excellent stability of the sludge digestion liquid treatment. The US-AnFMBR system achieves the recovery of nitrogen and phosphorus resources for subsequent agricultural recycling, and avoids the eutrophication of water ecosystems. Reclaimed water meets the nutrient requirements of typical crops during the growing season. To a certain extent, carbon emission reductions in agriculture can be achieved.

Keywords: agricultural reuse; anaerobic fluidized-bed membrane bioreactor; ultrasonic; biochar; sludge digestion liquid; membrane fouling (search for similar items in EconPapers)
JEL-codes: O13 Q Q0 Q2 Q3 Q5 Q56 (search for similar items in EconPapers)
Date: 2023
References: View references in EconPapers View complete reference list from CitEc
Citations:

Downloads: (external link)
https://www.mdpi.com/2071-1050/15/9/7698/pdf (application/pdf)
https://www.mdpi.com/2071-1050/15/9/7698/ (text/html)

Related works:
This item may be available elsewhere in EconPapers: Search for items with the same title.

Export reference: BibTeX RIS (EndNote, ProCite, RefMan) HTML/Text

Persistent link: https://EconPapers.repec.org/RePEc:gam:jsusta:v:15:y:2023:i:9:p:7698-:d:1141769

Access Statistics for this article

Sustainability is currently edited by Ms. Alexandra Wu

More articles in Sustainability from MDPI
Bibliographic data for series maintained by MDPI Indexing Manager ().