Study on gas–particle flow and combustion stability of an improved burner for different boiler loads

Chunchao Huang, Zhengqi Li, Yue Lu, Huacai Liu, Fan Fang and Zhichao Chen

Energy, 2025, vol. 316, issue C

Abstract: This study aimed to enhance the flexibility capability of thermal power units to address challenges in integrating renewable energy into the grid, especially stable combustion at low loads in faulty coal–fired boilers. A new improved swirl burner was developed and successfully applied to a 700 MW boiler. This paper enhanced testing conditions and focused on varying boiler loads. Gas–solid flow characteristics under different boiler loads were acquired through a cold experiment. Industrial measurements were conducted on–site, revealing gas temperature distribution. The burner could form an annular recirculation zone at 15%–20 % rated loads, demonstrating its potential for stable combustion at ultra–low loads. Boiler load significantly affected velocity distribution in primary and secondary air. The reflux ratio increased as the load decreased. At low loads, there was increased negative particle volume flux and recirculation. Load had little effect on the burner central temperature but correlated more strongly with the secondary air area temperature. Coal ignition distance was approximately 2.0 m in the center and near the exit in the secondary air region. Temperature differences in the secondary air area were minimal between 522 MW and 645 MW but relatively higher at 444 MW. Cold–state experiment results effectively explained hot–state phenomena.

Keywords: Swirl burner; Gas–particle flow characteristics; Deep peak–shaving; Steady combustion characteristics (search for similar items in EconPapers)
Date: 2025
References: Add references at CitEc
Citations:

Downloads: (external link)
http://www.sciencedirect.com/science/article/pii/S0360544225002002
Full text for ScienceDirect subscribers only

Related works:
This item may be available elsewhere in EconPapers: Search for items with the same title.

Export reference: BibTeX RIS (EndNote, ProCite, RefMan) HTML/Text

Persistent link: https://EconPapers.repec.org/RePEc:eee:energy:v:316:y:2025:i:c:s0360544225002002

DOI: 10.1016/j.energy.2025.134558

Access Statistics for this article

Energy is currently edited by Henrik Lund and Mark J. Kaiser

More articles in Energy from Elsevier
Bibliographic data for series maintained by Catherine Liu ().